Metallic-to-semiconducting nanotube conversion greatly improves transistor performance
share this!
Share
Tweet
Share
Email
May 28, 2013
feature
Metallic-to-semiconducting nanotube conversion greatly improves transistor performance
by
admin_andrey
, Phys.org
Add as preferred source
When copper nanoparticles are deposited on SWNT networks (left: aligned network; right: crossbar network), the nanoparticles create band gaps in the metallic SWNTs, which decreases leakage current and improves a transistor’s on/off ratio. Credit: D. Asheghali, et al.
(Phys.org) —Future transistors made of semiconducting single-walled carbon nanotubes (s-SWNTs) have the potential to perform much better than today's transistors. However, when SWNTs are grown in bulk, only about two-thirds of them are semiconducting, while the other one-third are metallic (m-SWNTs). Since m-SWNTs have a higher conductivity than s-SWNTs, their presence allows current leakage in a transistor's off state, which greatly decreases the transistor's on/off current ratio and overall performance. In a new study, scientists have demonstrated that simply decorating the m-SWNTs with copper oxide nanoparticles can convert them into s-SWNTs, resulting in a 205-fold increase in a transistor's on/off current ratio.
The researchers, Darya Asheghali, Pornnipa Vichchulada, and Associate Professor Marcus D. Lay at the University of Georgia in Athens, have published their paper on converting m-SWNTs to s-SWNTs in a recent issue of the
Journal of the American Chemical Society
Previous studies have attempted to overcome the problem of m-SWNTs by using methods that are often complex and expensive. Some approaches involve using specialized SWNT growth methods that select for s-SWNTs, while other approaches involve post-growth solution processing to remove m-SWNTs.
The approach proposed in the new study could provide a simpler solution to obtain large amounts of s-SWNTs. After growing the SWNTs using a conventional bulk growth method, the researchers deposited sub-10-nm
copper oxide
nanoparticles
on all of the nanotubes, both metallic and semiconducting. This single step converts the m-SWNTs into s-SWNTs and also improves the electric properties of the original s-SWNTs.
When the researchers incorporated these decorated s-SWNTs into
transistors
, they found that the transistors' on/off current ratios increased from about 21 to 4300, representing a 205-fold improvement.
The reason that the nanoparticles have this effect is because of the way they change the SWNTs' band gaps. Since a band gap is the energy range in a material where electrons cannot exist, generally a large band gap corresponds to low electrical conductivity, and vice versa. Typically, insulators have large band gaps, semiconductors have smaller band gaps, and conductors have very small or no band gaps.
In the current study, the m-SWNTs originally have no band gap, making them good conductors. Although high conductivity is good when transistors are in the on state (when electrons flow), it is a liability in the off state (where electrons don't flow). Being highly conductive, the m-SWNTs leak a lot of current in the off state.
As the researchers demonstrate here, the copper oxide nanoparticles can open up a band gap in the m-SWNTs, which restricts the current flow and greatly reduces the leakage current when the transistor is in the off state. Now that the m-SWNTs have a band gap, they are by definition s-SWNTs. The nanoparticles also increase the band gaps of the s-SWNTs, which improves both their uniformity and current efficiency.
The researchers explain that the copper oxide nanoparticles create/increase these band gaps by withdrawing electron density from the SWNTs at the point of contact. In a sense, the nanoparticles act like tiny valves along a wire that increase the SWNTs' sensitivity to gate voltages at certain points, changing the
conductivity
of the SWNTs overall.
Although the researchers describe the effect as a conversion of metallic SWNTs to semiconducting SWNTs, they also clarify that, when it comes down to it, m-SWNTs are not true metals. Instead, they should be considered semimetals or zero band gap semiconductors because true metals could not be made sensitive to the gate voltage.
Discover the latest in science, tech, and space with over
100,000 subscribers
who rely on Phys.org for daily insights.
Sign up for our
free newsletter
and get updates on breakthroughs,
innovations, and research that matter—
daily or weekly
Graphene also falls into this category of semimetals. However, it is more complicated to open a band gap in graphene because graphene is a 2-D material. The researchers explain that the 1-D nature of SWNTs simplifies the process of
band gap
tuning by allowing the nanoparticles to act like valves on a wire and locally halt electron transport. This approach cannot carry over to planar graphene due do its different geometry.
This relatively simple method of using nanoparticles to convert m-SWNTs into s-SWNTs, and the significant performance improvement that results, has great potential to further the development of SWNT-based transistors in the future, as well as carry over to other areas.
"The ability to open a bandgap in graphite-based semiconductors like SWNTs and graphene will have applications in sensors and energy conversion," Lay told
Phys.org
As for SWNT field-effect transistors (FETs), Lay explained that other challenges remain before they can become commercially widespread.
"The biggest problem facing SWNT FETs is the dearth of purification and suspension formation methods that separate the high aspect ratio SWNTs needed for structural and electronic applications from the soot and catalyst particles that make up about 50% of SWNT samples with common bulk growth methods," he said. "Another major roadblock is the lack of deposition methods that allow control over the density and alignment of SWNTs."
Lay and his group have contributed significantly to these two areas in another recent study
Publication details
D. Asheghali, P. Vichchulada, and M. D. Lay. "Conversion of Metallic Single-Walled Carbon Nanotube Networks to Semiconducting through Electrochemical Ornamentation."
J. Am. Chem. Soc.
, 2013, 135 (20), 7511–7522.
DOI: 10.1021/ja311721g
Note:
N. P. Bhatt, P. Vichchulada, and M. D. Lay. "Bulk Purification and Deposition Methods for Selective Enrichment in High Aspect Ratio Single-Walled Carbon Nanotubes."
J. Am. Chem. Soc.
, 134 (2012) 9352-9361,
DOI: 10.1021/ja302136x
Journal information:
Journal of the American Chemical Society
Citation
Metallic-to-semiconducting nanotube conversion greatly improves transistor performance (2013, May 28)
retrieved 24 April 2026
from https://phys.org/news/2013-05-metallic-to-semiconducting-nanotube-conversion-greatly-transistor.html
This document is subject to copyright. Apart from any fair dealing for the purpose of private study or research, no
part may be reproduced without the written permission. The content is provided for information purposes only.
437
shares
Email
Feedback to editors
Trending
Featured
Last Comments
For 74,000 years, one ancient killer quietly dictated where early humans could survive across Africa
Apr 22, 2026
Classical physics can explain quantum weirdness, study shows
Apr 22, 2026
Mars rover detects never-before-seen organic compounds in new experiment
Apr 21, 2026
Scraped from ancient Roman toilets, these crusted remains expose a pathogen found far earlier than expected
17 hours ago
Breakthrough sulfur polymer kills dangerous fungi and bacteria while sparing human and plant cells
Apr 21, 2026
How electron structure affects light responses in moiré materials
1 hour ago
A third of animal habitats on land could experience multiple extreme events by 2085, new study suggests
1 hour ago
This 2,200-year-old Roman wreck hid a repair story that rewrites how ancient ships survived long voyages
6 hours ago
New bioreactor turns stem cells into an immune-cell factory, producing 40 million human macrophages per week
10 hours ago
DNA damage just got more complicated: A long-missed weak spot emerges when light and oxygen strike
11 hours ago
Milky Way's 'little cousins' may hold clues about infant universe
11 hours ago
Moon dust could stop being a nuisance and start reshaping how humans may build beyond Earth
11 hours ago
These 'good' viruses hold up a booming industry—AI just found a faster way to track them
11 hours ago
Giant octopuses may have ruled the oceans 100 million years ago
12 hours ago
Life's earliest proteins may have folded into complex shapes with far fewer amino acids
12 hours ago
Relevant PhysicsForums posts
Trouble piecing together LS coupling
Apr 10, 2026
Edge of Brillouin zone,1D crystal, graphene, standing wave, band gap
Mar 22, 2026
Unexpected irregular reflection signal from a high-finesse cavity
Jan 6, 2026
Momentum density of silicon valence band using bandstructure
Dec 22, 2025
Monte Carlo simulation for the classical isotropic 3D Heisenberg model
Dec 3, 2025
Time rondeau crystals, experimental observations
Dec 1, 2025
More from
Atomic and Condensed Matter
Related Stories
Recommended for you
Riding the quantum wave: Quasiparticles reveal a magneto-optical transport phenomenon
14 hours ago
What's that swirly pattern? It's a moiré, and it has potential power
16 hours ago
Why does life prefer one 'hand' over the other? New study points to electron spin
Apr 22, 2026
First direct nanomagnet measurement finds switching attempts far slower than long-assumed
Apr 22, 2026
Laser bursts flip nanoscale magnetic vortices at blistering speeds, opening a path to brain-like spintronics
Apr 21, 2026
Put a nanodiamond under intense pressure and it becomes flexible
Apr 21, 2026
Load comments (0)
Get Instant Summarized Text (Gist)
This summary was automatically generated using LLM.
Full disclaimer
Let us know if there is a problem with our content
E-mail the story
Metallic-to-semiconducting nanotube conversion greatly improves transistor performance
Donate and enjoy an ad-free experience
We keep our content available to everyone.
Consider supporting Science X's mission by getting a premium account.
Remove ads
Maybe later
E-mail newsletter